172 Point Vehicle Inspection

ROAD TEST

• Engine Start / ldle (cold/warm)
• Operation / Performance / Acceleration
• Transmission Shifting (automatic/manual)
• Braking / ABS (operation)
• Steering / Alignment
• Transfer Case Operation (F/RWD, 4WD, AWD, Auto 4WD)
• Crusie Control (hold acceleration, cancel)
• Speedometer/ Odometer

UNDER HOOD

• Emission / Diagnostic trouble codes (meet state and local standards)
• Visual (loose/missing components/leaks)
• Electrical System / Battery / Starter (battery,cables,belts,charge)
• Engine Cooling / Radiator / Fan/ Fan Clutch (level, hoses,condition)
• Power Steering System (level,pump,lines)
• Brake System (level, master cylinder,lines)
• Ignition System(wires / condition/ routing)
• Fuel System (lines / leaks/ connection)
• Vacuum System (hoses / condition)
• A/C Compressor (leaks / operation)
• Belts / Serpentine (tension / wear)

FUNCTIONAL

• Seat Belts / Retractors (wear / operation)
• Mirrors (operation, heat, inside/outside)
• Indicator Gauges / Lights/Warning Tones
• Windsheild Wipers/Washers
• Tilt Wheel / Telescoping
• Sound System (radio,tape, CD, all speakers)
• Heater (blower / blend door ATC)
• Air Conditioning
• Horn
• Keys / Key Fob / Remote Start
• Rear Defogger
• Convertible Top (operation)
• Interior Lights (map lights/dash Lights)
• Exterior Lights (headlights/DRL'S/brake)
• Door Handles / Door Locks (power/manual)
• Fuel Door / Trunk/ Hatch Release
• Windows / Power/ Swing-Out(power/manual)
• Power Outlets/ Cigarrette Lighter
• Parking Brake
• Sun / Moon Roof
• OnStar
• Clock / Timer
• Console / Compartment Lid (front / rear)
• Overhead Console (compass / temp. reading)
• Visor (vanity light)

UNDER VEHICLE

• Inspection / Correction of all the fluid leaks
• Brake Pads,Shoes (condition, lining)
• Calipers, Rotors,Drums(condition)
• Brake Hydraulics (level / lines / hoses)
• Springs/ Sway Bars (mount / bushings/etc.)
• Control Arms(condition / mount/bushings)
• Steering Linkage (tie rods/ends,linkage)
• Engine / Transmission / Transfer Case & Mounting (leaks)
• Driveline/Driveshaft / Axles/Universal Joints
• Axles / Differentials (leaks / CV Joints)
• Gear / Rack & Pinion (leaks / mountings)
• Parking Brake Cable (condition / operation)

MAINTENANCE

• Lube / Oil / Filter and maintenance (reset oil life monitor)
• Inspect / clean air filter (replace if necessary)
• Inspect / change all other filters per manufacturer's schedule
• Inspect / Top-off Fluids
• Tire Presssure (check / adjust / rotate if needed)